For support please email or pm Christopher christopher@snowestonline.com



Upgrade to Premium
Yamaha: Boosted Sleds (Turbo or Supercharged) Turbo discussion for Yamaha aftermarket Turbo or Super Charged sleds.
Reply
 
Share Thread Tools Display Modes
  #1  
Old 01-29-2017, 04:50 PM
FBM FBM is offline
Currently: Not set.
Join Date: Dec 2008
Location: Tisdale Saskatchewan
Basic Member
Posts: 68
Thanks: 1
Thanked 16 Times in 11 Posts
Rep Power: 687741
FBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond reputeFBM has a reputation beyond repute
Default Temp Light

Put a new turbo section on my apex (alpine kit). Took it out for a test run. Sleds runs good. Rode it for 30 km then the temp light came on. Shut it off. Checked heat exchangers ( stock tunnel). Right side warm. Left side not as warm.The hoses going into aux rad considerably warmer than the exchanger. After 5 minutes started it , light was off. Drove it 5 minutes more , put it on the trailer, no light. Checked coolant this am , added a small amount to catch can, main tank right full. Took it out for another spin , 5 km the light is on. Shut it off for 5 minutes , light out head back home. Light on again , wait 5, light out. Drove it the km to the shop no light. I am thinking I don't have the cooling system bled properly?? Checked around the head looking for leaks. None I could see. Any thoughts? If it is a bleeding issue what is the proper procedure to bleed the cooling system?
Reply With Quote


Rate this post: Yes | No
  #2  
Old 01-30-2017, 12:20 AM
up-high's Avatar
up-high up-high is offline
Currently: New femur and a new knee and more metal in hip!!
Join Date: Nov 2007
Location: Alberta Canada
Age: 66
Posts: 1,483
Thanks: 45
Thanked 156 Times in 119 Posts
Rep Power: 17041864
up-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond reputeup-high has a reputation beyond repute
Default

Probably air in cooling system. If it's the stock tunnel, raise back of sled and loosen bleeder screw at back of tunnel. Let sit for a day. Should be good.
__________________
65/121 It don't get any lighter!
BERRGG

It's Mountainhorse time now!!!
Reply With Quote


Rate this post: Yes | No
The Following User Says Thank You to up-high For This Useful Post:
FBM (02-02-2017)
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Thread — 2008 XP800 summit x-shows shutdown/beeps/temp light/oil light Thread Starter — Snoghost Forum — Ski-Doo: XP Sleds Replies — 0 Last Post — 04-19-2016 02:28 PM
Thread — Temp light and check engine light in deep pow? Thread Starter — Blk88GT Forum — Ski-Doo: XM Sleds Replies — 16 Last Post — 02-24-2014 06:02 PM
Thread — Temp light on and rev light on and off flashing when going forward? Thread Starter — Brandonedge700 Forum — Polaris: EDGE Replies — 4 Last Post — 01-04-2014 12:13 AM
Thread — 8 flashes engine&temp light....Temp sensor? Thread Starter — ringercord Forum — Yamaha: 2-stroke Replies — 0 Last Post — 01-27-2013 12:30 PM
Thread — temp light is tach shift light on a 03 900 M1 Thread Starter — coug66 Forum — Arctic Cat: 1M Replies — 4 Last Post — 01-03-2011 09:38 PM

All times are GMT -6. The time now is 03:59 PM.